A reply to some client questions.

added by russ on September 9, 2016 at 08:39

Copied here because many of the questions are fairly common ones!

All our craft use Briggs & Stratton Vanguard engines.  Built in Japan by Daihatsu, they are low revving four-strokes, which means decent noise levels and very good economy. Snappers use around 4-5 litres of fuel an hour, Marlins maybe 6-7 (much less than a jet ski!) They use regular UK/US pump fuel, no need for anything special.  Both will get around 2-4 hours from a fuel tank (12 litres on Snapper, and 25 on a Marlin) but of course it depends on conditions, payload, wind and the driver.

Maintenance is (in brief) as follows.

Pre-operation, check the craft over. Visually inspect skirt fix and wear, oil levels, fan condition, belt etc. Takes a couple of minutes per craft.

After a days operation in salt water, wash the craft off thoroughly with fresh water. Allow five minutes per craft.

If skirt needs maintenance, you can change each segment individually (approx. 58 on a Marlin/52 on a Snapper) and it takes just two minutes. The skirt – on water – will last a very long time, you’re likely to get well over a year from them. Sand/Mudflats/gravel obviously wear it faster but its top quality material and designed especially for us by a 'technical materials' company.

At 50 hours, change the oil, adjust tappet clearances, check fuel and air filters, replace if necessary.

How long do they last?

We have customers operating with over 600 hours on their engines, mechanically they are very robust (they are for plant/commercial use remember!) but you may replace ancillaries such as carburetors/coils etc in time. A whole new engine is only £1250.00UK so its not an expensive purchase if the worst happens. I’d certainly hope you got 5-10 years use from the craft, but of course, it depends largely how well they are looked after and the hours they clock up. We keep absolutely everything to build them (of course!) so there's nothing cannot be replaced, even the hulls which (to answer your next question) are built from GRP Fibreglass.

Wave capacity

It's difficult to be too precise about but they are all okay in a ‘chop’ – you must remember they are only small – so whatever you may be comfortable in a small boat of the same size, the hovercraft will be okay too. It’s a common question, and you may find this interesting and useful. http://britishhovercraft.com/UploadedFiles/hovercraft%20performance%20and%20information.jpg Also our FAQ page - http://britishhovercraft.com/Buy-A-Hovercraft/Frequently-Asked-Questions.aspx

Which Marlin?

For your use I’d recommend the Marlin ‘Beast’ – it has lots of extras and has more 'kerb appeeal' than the Marlin II Freestyle. The Marlin III is the best of everything, but it costs more money and isn’t really necessary for your purposes.

Marlin II : £9,500.00 - No frills, all thrills hovering!

35bhp Briggs & Stratton Engine

Yellow beacon

Bilge Pump

Jockey Seat for two

Hour meter

Kevlar reinforced floor

Internal Buoyancy foam

Limited range of colours. White hull with either blue or red trim.

 

 

 

The Beast : £11,000.00 - As driven by Jeremy Clarkson!

As above but with the additions of

37bhp Hi-Torque 'Savage' engine.

Rear 'T' Seat - more seating for up to three people.

All-round LED white light and navigation lights.

LED Headlights.

Rubber non-slip flooring.

Improved endplate rudders.

Tacho/Rev Counter.

GPS Speedo/heading compass.

Wide range of hull and secondary colours .

 

 

Marlin III : £12,500.00 - The ultimate yacht tender!

As 'The Beast' but with the following additions.

Upgraded, stiffer hull with integrated screen, revised splitter plate to reduce noise and add additional lift, larger receiver area to give improved plenum flow characteristics.

 

 

Lots more answers to many more question on our website!

 

 

 

 

British Hovercraft Company - Play Day for friends and family!

added by russ on June 23, 2015 at 09:12

It's been a pretty mental few months now and at times, the order book has rather outstripped production! But the team working in production have risen to the task brilliantly - working, quickly and efficiently and putting extra hours in as required to make sure that customer orders have been completed on time - we're are genuinely grateful for their efforts.

As a bit of a thank you, we decided to throw another one of our 'play days' where we invite the familes and friends to come along for a drive in the safety of our demo track in Sandwich. Some vigourous work with the mower, rakes and water pump (to refill the bone dry pond!) gave us a useable track, Emma's new exhibition trailer (of which she is rediculously proud and excited!) was pressed into use as the corporate centre (we're not quite Red Bull Formula One yet!) and a huge BBQ thrown together from an empty acetone drum, base made from an old trailer chassis and off-cuts of hovercraft fan ducts providing the grill!

All in all, a quick and dirty bit or organisation which worked out just great. I was responsible for the weather (which was gorgeous) and we got really lucky when a stunt plane turned up and put a spectacular display on for the show in the next field over... result! Nobody died of food poisoning, dozens of people drove a hover for the first time and the kids and dogs were completely exhausted when we finished up around 6pm.

A great day, thanks so much to all our staff for their hard work, and friends and family for coming along and helping out.

Here's a few photographs from the day, mostly courtesy of my Auntie Brenda!

 

 Awesome show - Pitt Special?

 The peace and tranquility of an English summers day!

 

I taught a lot of people to drive... successfully too! :-)

Gary soaking the girls. 6 years old and they love it...2 years old and they hate it!

Your never too old to try it - right uncle?

Emma's trailer..next stop the vinyl wrap ready for some shows.

And you're never too young either - 10 year old Kai drove the Snapper like a boss! ("Daaaad? Can I race one next year....?")

Carbon Fibre Integrated Hovercraft....no, not really the answer!

added by russ on May 28, 2015 at 10:23

Unfortunately, the days of cross channel 300 ton monster hovercraft are behind us, killed off by many factors - unavailability of engine servicing, increased fuel costs and finally, the end of duty free.

Nowadays, the Russian Navy ZUBR, and the US Marine LCAC's operate the world's largest hovercraft. Here in the UK, the Hovertravel AP1-88 flies the flag for the largest craft in the UK.

Down at the ‘other end’ of the scale, our original single seat ‘Snapper’ of 1998 now has a larger sibling in the shape of the Coastal-Pro, a 3-4 seat commercial craft which has been selling well to people who need a practical, safe and effective hovercraft for such uses as transport on frozen rivers, through tidal estuaries and over mudflats.

The biggest difference between the Coastal-Pro and our earlier hovercraft (the Marlin, Snapper and Mark One Coastal-Pro) is that it uses a separate lift system, which is controlled independently from the thrust system. Our smaller hovercraft use just one engine to give both lift and thrust, a system which works really well on smaller hovercraft but is redundant by the time the craft gets to 3 seats/4m or so. The Coastal-Pro is the first of these twin-engined hovercraft from BHC, but larger ones will follow.

 

As a result the Coastal-Pro can lift over 300kgs from a dead-start on water, and carry considerably more on land or over water without needing to stop. The earlier craft without he separate lift engine displayed some shortcomings in this area, which is why the  new Coastal-Pro was born. Quite simply, larger hovercraft don’t work with a single engine and fan.

Interestingly, one company has recently released an integrated 5m hovercraft built from Carbon Fibre which they claim is capable of seating (variously!) seven to nine people or an astonishing half-tone payload – from a water start, this is a hovercraft’s biggest challenge. Of course, none of the videos actually show it doing so with 7 people on board (just big cardboard boxes in the back full of what I wonder? Air?) If you have a desire to never hear again, take a look at a video of it in action (WARNING : HEARING DAMAGE VERY LIKELY!) VIDEO

The whole design concept of a 7 seat integrated hovercraft is simply wrong. It’s a fundamental design flaw akin to building a 400bhp three wheel Ferrari or an aeroplane with one wing. This particular example is powered by a 120bhp turbocharged engine – huge complexity and noise levels fit to burst eardrums (this, from our analysis is around 96dbA at 25m, loud even for a racinghovercraft!) A carbon fibre hull is space rocket technology stuff, sure. But in hovercraft use, it’s brittle and shatters quite easily, a more useful design would be to back it up with Kevlar (something we and many others have learned from racing hovercraft over the years of competition) – on its own, it’s a poor choice.

The problems can be seen quite clearly on the promo videos, the integrated design means very poor hover height, the hovercraft never truly hovers which means the skirt is dragging and will wear out in no time. Worst case, poor hovering can mean it will catch the ground travelling sideways and stop dead or flip over…ouch!

You cannot simply ‘’scale up’ small hovercraft and expect them to work as well – there has to be limits, and this one’s been crossed - and here's the result.

Meanwhile...put your fingers in your ears, turn down the volume on your PC and and play THIS VIDEO!

Take a look at this photo - wow! No words needed!

 

 

The bottom line is that despite being a much smaller hovercraft, our Coastal-Pro (all 65bhp of it) will outperform this 5m, 120bhp offering. It’s around 1/3rd of the noise level, three times as economical, carries just as much payload, is easier to drive, more reliable (seriously – a turbocharger and extensive electronics in a saltwater environment???) – oh, and much prettier! :-)

All those years of R&D, racing, cruising, commercial work and using our own craft in every conceivable environment have given The british Hovercraft Company unmatched experience in the design and production of real, working hovercraft. No bull, no wild figures, no opinion – we’re proud to say our hovercraft perform exactly as promised in our literature and on this website

By all means, try out other hovercraft brands – then come along to us for a demo, we’ll be happy to see you and demonstrate the advantages of a clear design philosophy.

For demonstrations, please call us on 01304 619820

 

 

The US approves of the new Coastal-Pro Hovercraft!

added by russ on November 18, 2014 at 05:01

Selling hovercraft into the USA is a good thing - Americans are demanding clients (which is why my top holiday tip is always to head for resorts which are aimed at the US market - rather than European ones!) and in order to please the US client, we have to make sure the hovercraft we sell are better than good. This of course starts at the design stage, but follows right through manuufacturing to ensure we provide consistent high quality, hassle free products. Having clients that expect the best products simply drives us to produce the highest possible quality hovercraft.

Last weekend, our US dealer, Jason Keuhn from Hoverstream visited us to try out the new Coastal-Pro and was delighted. A full day on the River Medway clocked up some 40 miles exploring some of the historic sights and a visit to a traditional English pub for a beer with some flavour was a suitable finale!

As you can see  from the copy of Jason's facebook post below - he was very happy with the new Coastal-Pro (in fact he came back to our factory the and immediately ordered three!) and I may be biased but I have to agree with him. We honestly believe there is nothing else on the market which comes close in terms of performance, low noise, handling  and looks. We set out to create the best small hovercraft on the market today and are absolutely delighted with the results!

Hovercraft review by Jason at Hoverstream

The new Coastal Pro is here, and it changes everything. More space, more payload capacity, more thrust, a separate lift engine, quieter, and a wicked new look equals one incredible hovercraft!

We were recently fortunate enough to spend a day in England trying out one of these new beauties, and boy are we impressed! First of all, special sound deadening material in the front screen combined with the larger, slow turning thrust fan make the whole thing surprisingly quiet. Second, the separate lift engine offers a huge advantage with heavy payloads, especially on ice or in tight quarters where maximum maneuverability is important. Third, and perhaps most importantly, it's simply a pleasure to drive. There is just nothing else like it on the market.

 


Search


Categories

None


Tags


Archive


Recent Posts